Kia Soul EV: Air Conditioning System / Components and Components Location

Kia Soul EV (PS EV) 2015-2020 Service Manual / Heating,Ventilation, Air Conditioning / Air Conditioning System / Components and Components Location

Component Location Index

Engine Room

[Without Heat Pump]

1. Receiver-drier
2. Condensor
3. A/C Pressure Transducer (APT)
4. Service port (Low pressure)
5. Service port (High pressure)

6. Suction & Liquid tube
7. Expansion valve
8. Suction pipe
9. Suction hose
10. Electric A/C compressor

[With Heat Pump]

1. Electric A/C compressor
2. Receiver-drier
3. Exterior condensor
4. Refrigerant temperature sensor #1
5. Chiller

6. 3 ways solenoid valve assembly
7. Accumulator
8. 2 ways solenoid valve assembly
9. Refrigerant temperature sensor #2
10. Expansion valve

Interior

1. Photo sensor
2. Heater & Blower unit

3. Evaporator temperature sensor
4. Heater & A/C control unit

Repair procedures

Refrigerant System Service Basics • Since the electric compressor uses high-voltage, POE oil with high volumetric resistivity should be used. • Do not use the same A/C recovery ...

Compressor Oil Repair procedures

Oil Specification 1. The HFC-134a system requires synthetic compressor oil (POE) whereas the R-12 system requires mineral compressor oil. The two oils must never be mixed. 2. Compressor oi ...

Other information:

Kia Soul EV (PS EV) 2015-2020 Service Manual: Description and Operation

Description The system temperature is calculated by the BMS based on 8 temperature sensor signals. And the cooling fan is conrolled in 9 steps to maintain the normal temperature of high voltage battery system. The air-cooling method is applied in the cooling system where indoor air is used ...

Kia Soul EV (PS EV) 2015-2020 Service Manual: Multimedia Jack Repair procedures

Removal 1. Disconnect the negative (-) battery terminal. 2. Remove the floor console upper cover. (Refer to Body - "Floor Console Assembly") 3. Remove the multimedia jack (A). Installation 1. Install the multimedia jack. 2. Install the floor console upper cover. 3. Connect ...