Kia Soul EV: Body (Interior and Exterior) / Troubleshooting
Kia Soul EV (PS EV) 2015-2020 Service Manual / Body (Interior and Exterior) / Troubleshooting
| Troubleshooting |
| Symptom | Possible Cause | Remedy (Refer to page) |
| Water leaks from panorama sunroof | Deteriorated roof lid weatherstrip | Replace |
| Excessive roof lid-to-body clearance and improperly fitted weatherstrip | Adjust | |
| Wind noise around panorama sunroof | Loose or deformed deflector, gaps in body work | Retighten adjust or replace |
| Noise heard when opening/ closing panorama sunroof | Foreign particles lodged in guide rail | Check drive cable and guide rails for foreign particles |
| Loose guide rails and lid | Retighten | |
| Motor runs but panorama sunroof does not move or moves only partially | Foreign particles lodged in guide rail | Adjust or replace |
| Incorrect engagement of motor pinion with drive cable | ||
| Decrease in motor`s clutch slipping force | ||
| Increased
panorama sunroof sliding resistance or interference of panorama sunroof
with drive cables, weatherstrip, etc. due to maladjustment of panorama
sunroof | ||
| Noise in motor (clutch slipping noise from motor when panorama sunroof is fully opened or closed is considered normal) | Incorrect engagement of motor pinion with drive cable | Check pinion installation and |
| Re-tighten motor | ||
| Worn out or damaged motor pinion bearing | Replace motor assembly | |
| Worn out or deformed drive cable | Replace | |
| Door glass fails to operate up and down | Incorrect window glass installation | Adjust position |
| Damaged or faulty regulator arm or regulator | Correct or replace | |
| Door does not open or close completely | Incorrect door installation | Adjust position |
| Defective door check assembly | Correct or replace | |
| Door hinge requires grease | Apply grease | |
| Hood does not open or close completely | Striker and latch not properly aligned | Adjust |
| Incorrectly installed hood | Adjust | |
| Incorrect hood bumper height | Adjust | |
| Water leaks through windshield end rear window | Defective seal | Fill with sealant |
| Defective flange | Correct |
Special Service Tools
Special Service Tools
Tool Name / NumberIllustrationDescriptionHog ring clip installer09880-4F000Used to install hog ring clip
Personal Protective Equipment
NameIllustrationDescriptionInsu ...
Other information:
Kia Soul EV (PS EV) 2015-2020 Service Manual: Rear Wheel Speed Sensor Repair procedures
Removal 1. Remove the rear wheel & tire. Tightening torque: 88.3 ~ 107.9 N.m (9.0 ~ 11.0 kgf.m, 65.1 ~ 79.6 lb-ft) 2. Remove the rear wheel speed sensor. (Refer to Driveshaft and axle - "Rear Hub - Carrier") 3. Install in the reverse order of removal. ...
Kia Soul EV (PS EV) 2015-2020 Service Manual: Rear Torsion Beam Axle Repair procedures
Replacement 1. Loosen the wheel nuts slightly. Raise the vehicle, and make sure it is securely supported. 2. Remove the front wheel and tire (A) from front hub. Tightening torque : 88.2 ~ 107.8 N.m (9.0 ~ 11.0 kgf.m, 65.0 ~ 79.5 lb-ft) • Be carefu ...
Copyright © www.ksoulev.com 2020-2024
